Our metal panel product introduction

The panels are resistor welded from steel hot-dip galvanized rods, which are 5 mm or 4 mm thick and then protected by a plastic covering – an electrostatic powder coating and heated at 200 ºC. This process enables our panel fences to become completely protected against rust and they require no maintenance or painting as we provide rust-free guarantee for a period of 10 years, if no physical damage is caused to the fence (scratches, impacts). 

Panels can have various heights – 600 mm, 1000 mm, 1200 mm, 1500 mm, 1700 mm, 2000 mm, 24 00 mm. According to their height, they are reinforced in their entire length with stamped V-shaped reinforcements adding strength and stability to the panel. The panels of 600 mm, 1000 mm and 1200 mm have 2 reinforcements; 1500 mm and 1700 mm have 3 reinforcements, while 2000 mm and 2400 mm have 4 reinforcements. 

The panel length is standardized – 2.5 m. Plastic coveting offers a wide selection of possibilities within the RAL color scale. Standard colors are green RAL 6005, which our clients prefer as it merges best with the surroundings of houses, gardens and parks, a standard selection are also shades of grey RAL 7015, 7035, 7040, which match modern business buildings and asphalt parking lots. 

For private residential houses, our customers most often choose the following heights: 1000 mm, 1200 mm and1500 mm; for decorative gardens 600 mm; and for business buildings 1700 mm and 2000 mm. Our fences are available in all colors within the RAL color scale. Our standard colors are green and gray, all other colors from the RAL color scale are available upon a previous order. 

Our panel fences are made from solid steel hot-dip galvanized rods (diameter 5 mm), where the application of zinc is min. 80g/m2. The fence panels are covered with plastic electrostatic powder coating and baked at 200 ºC. Our standard color is green RAL 6005, however, you can order your fence in any desired color from the RAL color scale. Glazing: according to standard (ISO 2813) at an angle 60,95%Adhesion: according to standard (ISO 2409) Durability: according to standard (EN 48252) more than 80.Thickness of the layer of applied rust resistant polyester is min. 120 micron.

The usage and features of barbed wire

The barbed wire is made of fully automated barbed wire, which is a kind of guardrail. Barbed wire, also known as barbed wire, barbed wire, folk commonly known as Tribulus terrestris. Barbed wire is the barbed wire wrapped in the main wire twisted from the isolation, protective products, in the construction of a straight line installation and spiral cross form.

We products

Raw materials: high-quality low-carbon steel wire (galvanized, plastic, spray) PVC wire; blue, green, yellow and other colors. PVC barbed wire can be galvanized wire and black wire

Types of barbed wire: single wire twist and double wire twist.

Weaving and features: twisted from; solid, beautiful.

Weaving process: twisted from; galvanized

Features: Blade barbed wire, is a developed in recent years, the protection of a strong isolation of new protective net products. It is stamped with steel plate attached to the wire (wire) above, by the sharp sharp angle galvanized steel or stainless steel sheet to do the blade, high-tension wire made of a combination of wire. 

Sharp knife stabbed by the double line after the buckle into a snake-like, both beautiful and shudder. Played a very good deterrent effect.

Usage: The world has been widely used in the military grenades, prison, government agencies, banks; living area walls, private homes, villas walls, doors and windows, highways, railways and border protection protection.

Double Wire Fencing

Panels
The mesh aperture for this twin-wire type of welded mesh fence is 200mm x 50mm. Twin horizontal wires at each intersection give a rigid but flat profile to this mesh fencing system, with vertical wires at 6mm and horizontal wires either 6 or 8mm depending on the height of the mesh panel and the site application. 

The height of the mesh panel can be from 1.0M up to 2.4M, with the finish galvanized and polyester coated in a range of standard RAL colors. This system not only makes the panel extremely strong and stable but also makes the panel extremely difficult to cut through. 

The twin wire mesh fencing system is amongst the most comprehensive, cost effective security fencing systems in the world today.

Introduction
Stopping people from cutting through or climbing over your fencing system is essential for schools, sports grounds and many other public places. LinkLand™ prevents both, with its double wire system acting as a solid barrier and panel heights of up to 6m

serving as a mighty obstacle.
Each steel panel features twin 8mm wires welded either side of 6mm vertical wires, giving would-be intruders little chance of breaking through.Panels are fixed to steel

posts using sturdy clamps and secured with pin hex security screws, with no visible fixings on the back of posts.

Advantage of T post

1, it is the same section size of ordinary steel compared to its mechanical properties and physical performance improvement rate of 30% or more;

2, nice appearance, easy to use, low prices;

3, it is directly into the soil with a piling machine, do not destroy the vegetation, a few years later can also be recycled, in line with national environmental requirements, is environmentally friendly products.

4, anti-theft performance is good, because it is a special product, no other use, it is not easy to be stolen.

5, it is China is currently using the ordinary angle column, cement products column and bamboo products column of the upgrading of products

The performance of the mechanical properties and physica

l properties of more than 30%; 

2, cattle bar net column appearance nice, easy to use, the price, the price of the steel bar and the same cross-section of the general steel, Low; 

3, cattle column column column is directly into the soil with a pile into the soil, do not damage the vegetation, a few years later can also be used back, fit the country's environmental needs, is environmentally friendly products. 

4, anti-theft performance is good, because the barrel column is a special product, no other use, it is not easy to be stolen. 

5, it is currently in use in China is the general angle column, cement products column and bamboo products column promotion products

China Qunkun Metal Supply 358 Security Fence

358 Security Fence Introduction:

358 anti climb fence is the fencing system made of generally wire mesh panel fences. The fence panel has close mesh opening and horizontal wires that make it an incredibly robust fencing. This system has good visibility and is also aesthetically pleasing.

High security fencing system is now rapidly growing in uses. Panels can be palisade type with sharp tops, posts type and railing types. The fence panels can be also made of common welded mesh wire, expanded metal fencing or other metal materials.

358 Security Fence Advantages:

358 anti climb fence is in high security perimeter protection, this system is extensively used when defendable space is paramount, used throughout the world in varying application.

358 fence is extremely difficult to penetrate, with the small mesh aperture being effectively finger proof, and extremely difficult to attack using conventional hand tools.

Australia Temporary Fence

The Temporary Fencing Panels are an ideal solution for temporary site security. The panels are extremely resilient and are suitable for multiple use. LinkLand Temporary Fencing easy to construct into a system and can be assembled to form a straight run of panels or joined together so that it forms an enclosure around a specific area.

This Temporary Fencing Panel is made from steel and is provided with a galvanized finish, which consists of a zinc coating to help prevent rust. The panel has a sturdy outer frame which is formed from 38mm or 42mm diameter round steel tubes. The panel also contains a mesh infill which helps to make it wind-resistant, so it’s stability can be maintained even in open areas. The apertures within the mesh are also smaller than a Standard Temporary Fencing Panel, which makes the panel more difficult to climb.

Preparing for Installing a Chain-Link Fence

Tools & Materials

• Tools
• Measuring Tape
• Post Hole Digger
• Wheelbarrow
• Shovel
• Hoe
• Carpenter's Level
• Wrenches
• Hacksaw
• Fence Stretcher
• Pliers
• Chalk Line

Materials

• Stakes
• Concrete Mix
• Fence Fabric, Posts and Other Materials

Step 1
Locate your property's boundary lines. It's recommended that all posts be set approximately 4 inches inside the property line so that concrete footings don't encroach onto any adjoining property.

Step 2
Measure the overall length of your planned fence to determine how many feet of chain-link fabric and top rail will be required .

Step 3
Mark the location of each terminal post (corner, end and gateposts are called terminal posts) with a stake. When determining the positions of gateposts, remember that clearance for hinges, latches, etc., is included in the listed opening width of the gate. Therefore, if you ordered a gate for a 36-inch opening, the post spacing should be exactly 36 inches, inside post face to inside post face.

What is 358 fence?

"358" is called from the fence of the mesh size is 3 "× 0.5", 8 refers to its wire number, converted into mm is 4mm, so that 358 fence size is 76.2mm × 12.7mm × 4mm. (Hole length × hole height × wire diameter).

358 fence mesh is narrow, easy to be objects through, so small mesh with traditional hand tools is difficult to cut it. Even difficult to climb, play the greatest protective effect, it is called safety fence, also known as high-strength fence. 358 fence mesh part can also be used in the form of bending, enhance the aesthetic effect. The 3510 fence has a variety of features 358 fence, its main advantage is the strength, light weight. With 3mm wire instead of 4mm will have better visibility, and cheaper, more widely used.

two common specifications of 358 Fence (long × high × diameter):

① 358 Fence (358 Fence): 3 "× 0.5" × 8 # that is 76.2mm × 12.7mm × 4mm.

② 3510 Fence (3510Fence): 3 "× 0.5" × 10 # that is 76.2mm × 12.7mm × 3.2mm.

Mesh Panel Size:

① Mesh Panel Height: 2.0m - 2.5m.

② mesh width (Mesh Panel Width): 2.5m - 3m.

Pls contact us if you want to buy 358 fence.

Introduction of different materials of steel fence

1.Steel fence style is usually with the art of the fence railings, known as the iron railings, iron railings are usually used to manually twist, to create a molding, can also be used hot metal casting molding. Iron railings look nice, with a strong ornamental, but also with the role of protection and decoration. Patterns can be produced according to individual needs. Selection of raw materials can choose galvanized steel, and the surface treatment can choose anti-corrosion than the occasional spray paint, fluorocarbon paint, and the choice of paint required primer and topcoat treatment, so as to achieve better corrosion and rust Effect, the surface of the paint processing color is usually black-based color, iron surface color can also be handled according to the corresponding needs.

2.Steel fence compared with the ordinary fence railings, the height is relatively high, so the requirements of the material more solid, and thus more solid. Most iron railings are installed in open air and are susceptible to rainwater corrosion. So the choice of raw materials can choose galvanized steel, and surface treatment can choose a better anti-corrosion than the spray paint, fluorocarbon paint, and the choice of paint required primer and topcoat treatment, so as to achieve better anti- Rust effect, the surface of the paint processing color is usually black-based color, the surface color can also be handled according to the corresponding needs of customers.

Chain link fence combination

Chain link fence is also called diamond wire mesh,it mainly used in sports field,basket field,park,garden,green field,parking field,architecture,waterways,residence safeguard,etc.Chain link fence is combined with blew elements.

1. Chain Link Fabric
Description: Woven wire usually made from galvanized or PVC coated galvanized steel wire. The wires run vertically and are bent into a zig-zag pattern so that each "zig" hooks with the wire immediately on one side and each "zag" with the wire immediately on the other. This forms characteristic diamond pattern seen in this type of fence.
2. Line Wire
Line Wire is used to secure fence fabric.
3. Tie Wire
To secure fence fabric to line wire.
4. Stirrup Wire
5. Stretcher Bar
Description: Typically made out of 25x5mm thick MS flat bars weaved through end mesh and secured after stretching the fabric at strainer posts.
6. Intermediate/Line Post
Description: Mild steel tubes, Galvanized or powder coated, placed usually about Three(3) meters from each other to support the fence, in variety of diameters (usually around 42mm to 60mm) and wall thickness.
7. Straining Post
Description: Usually used either at ends of a chain link fence, or where the fence bends or at suitable distances (usually around 30 meters) when the fence is running in straight line for long distances.
8. Corner Post
Description: Usually used either at ends of a chain link fence, or where the fence bends or at suitable distances (usually around 30 meters) when the fence is running in straight line for long distances.
9. End Post
Description: Usually used either at ends of a chain link fence, or where the fence bends or at suitable distances (usually around 30 meters) when the fence is running in straight line for long distances.
10. Horizontal Support
Description: Mild steel tube, galvanized or powder coated, fixed horizontally between Straining post and Intermediate post. The End/Corner/Straining posts are under stress from the stretch of chain link fence fabric. The horizontal support or brace helps spread the stress out over both the terminal post and the next intermediate post in line.
11. Truss Rod
Description: Installed at bottom of a terminal post (end/straining or corner post) to the two-third height of the adjacent intermediate post, pulls the horizontal support/brace towards the terminal post, in the process counteracts the pull from the stretch on the chain link fabric.It is threaded at one end. Commonly used diameters are around 10mm. Length depends upon the distance between the straining post and the intermediate post.
12. Top Rail
Horizontal member of the framework running from terminal post to terminal post on top of the line posts.
13.Barbed Wire

diamond wire mesh

China Qunkun Metal Supply Palisade Fence

My factory are Professional Of wire mesh fence ,such as Palisade Fence,
Welded wire mesh fence and so on.
Palisade Fence Description.
Palisade fence is also known as Euro Fence.It was first used in UK,now it is at home and abroad has been widely.Used as its beautiful architecture and various styles.Palisade fence ius divided into W-tyoe and D-Type fence according to the shape of the cross sections.
If you have any demands,you can contact me and I will send you a quotation.
ShijiazhuangQunkun Metal Product Co., Ltd is a premier manufacturer and supplier of wire mesh product located in Anping Town, the famous Wire Mesh Land of China. We have engaged in wire drawing, wire mesh weaving and metal fabricating for about ten years and have accumulated rich experiences in this field.

Palisade Fence

Palisade Fence